2018 Gillig Low Floor recalls
13 NHTSA recall campaigns naming the 2018 Gillig Low Floor. Last verified Jul 30, 2026. Recalls may apply only to certain VIN ranges — always confirm with a VIN check.
Units are totals reported across campaigns mentioning this model — NHTSA does not always break unit counts down by model.
Affected components
Nearby model years
Check whether your specific vehicle is affected
Recall campaigns often cover only certain VIN ranges. Enter your VIN on the official NHTSA site to confirm whether your vehicle is included and whether the repair is still open.
Check VIN on NHTSA →Campaigns
- Apr 25, 2022Crash risk2014–2021 Gillig Low Floor — Electrical System
Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
22V276000 · 592 units · Gillig, LLC
- May 14, 2021Fire risk2017–2020 Gillig Low Floor — Fuel System, Diesel
Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
21V352000 · 4K units · Gillig, LLC
- Jul 2, 2020Crash risk2013–2020 Gillig Low Floor — Steering
Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
20V392000 · 531 units · Gillig LLC
- Jun 10, 2020Crash risk2018–2020 Gillig Low Floor — Suspension
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.
20V342000 · 4K units · Gillig LLC
- Apr 29, 2020Crash risk2018–2020 Gillig Low Floor — Fuel System, Other
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.
20V239000 · 275 units · Gillig LLC
- Mar 25, 2020Fire risk2012–2020 Gillig Low Floor — Electrical System
Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
20V179000 · 8K units · Gillig LLC
- Jun 14, 2019Crash risk2018–2019 Gillig Low Floor — Structure
Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.
19V451000 · 25 units · Gillig LLC
- Mar 8, 2019Crash risk2014–2019 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
19V193000 · 965 units · Gillig LLC
- Jan 28, 2019Crash risk2016–2018 Gillig Low Floor — Steering
Gillig LLC (Gillig) is recalling certain 2016-2018 Low Floor buses. The ball stud of the steering system draglink may not have been properly tightened.
19V059000 · 4K units · Gillig LLC
- Nov 9, 2018Crash risk2013–2018 Gillig Low Floor — Parking Brake
Gillig LLC (Gillig) is recalling certain 2013-2018 Gillig Low Floor transit buses equipped with disk brakes. The spring cage bolts on the air brakes may not be sufficiently tightened, reducing the effectiveness of the parking brake.
18V789000 · 4K units · Gillig LLC
- Sep 25, 2018Crash risk2017–2018 Gillig Low Floor — Power Train
Gillig LLC (Gillig) is recalling certain 2017-2018 Gillig Low Floor transit buses equipped with certain Allison transmission hybrid drive units. The pressure switches on these Drive Units may fail, possibly resulting in a loss of drive.
18V665000 · 90 units · Gillig LLC
- Aug 9, 2018Crash risk2012–2018 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2012-2018 Gillig Low Floor vehicles. The front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
18V511000 · 178 units · Gillig LLC
- Jun 20, 2018Crash risk2001–2018 Gillig Low Floor — Exterior Lighting
Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
18V418000 · 26K units · Gillig LLC